1991 Porsche 964 Carrera 2

Oil change (Valvoline VR1 5w50, 11L), oil filter, distributor belt replacement, new Michelin tires (225/45/17 front, 255/40/17 rear), fuel pump, right front stabilizer link, autoradio replacement, tire mounting & balancing, A/C gas charge, pre-ITV general overhaul.

Muffler Bypass Pipe, Pedal Set 911/964/993, Transmission Mount, Front Control Arm Bushing Kit ×2 (Clubsport), Complete Tie Rods ×2 (Monoball Sport), Rear Trailing Arm Bushing Kit (Clubsport), Front Ball Joints ×2, FVD Mass Air Flow Meter Performance Kit (+20–50hp), Clutch Release Fork & Shaft Kit...

Front and rear suspension spring sets, stabilizer bearings (×2), rear suspension stabilizers (left & right), front suspension stabilizers (left & right), stabilizer bars — complete suspension spring and anti-roll bar renewal.

FVD Sport Catalytic Converter (200-cell, ø110mm) with installation kit. Short Shift Kit 964/993 (40% throw reduction).

BILSTEIN Front Shock Absorbers 964 C2 + C4 / 965 — B6 (Left + Right).

Exterior bodywork disassembly, mechanical disassembly, and interior bodywork disassembly — complete vehicle strip-down for restoration.

Rear crossbeam replacement, complete green carpet set and additional carpet set, interior trim parts.

Replace rear front panel, repair left rear roof area and drainage outlet. Prepare and paint bodywork. Paint satin black areas on doors, fenders, sills. Paint rear wheel arches. Preparation and painting materials.

Complete weatherstrip and seal renewal — soundproofing plates, windshield gasket frames (×2), all cabin soundproofing (front, rear, seat, top/bottom tray, motor insulation), cable sheathing, rubber gaskets for sills, door handles, mirrors, hood, fender seals, window triangle seals, felt door fram...

Oil cooling system overhaul: lateral oil pipes (×2), silemblock oil cooler, silemblock oil thermostat, oil tank silemblocks (×2), tank and thermostat oil pipes, oil cooler support. Plus window glass boxes (×2), rubber wheel plugs, headlight screws, sliding roof hardware, brake hardware (deflector...

Engine internal components: rocker arm swing axles (×12), set of bedplate bushings, connecting rod bushing set, No. 8 bushing, intermediate shaft bushings, upper and lower gasket sets, intake valve guides (×6), exhaust valve guides (×6), rocker arm shaft O-rings (×24), clutch pump, oil filter, oi...

Complete brake overhaul: front brake discs (×2), front brake pad set, rear brake discs (×2), rear brake pad set, front & rear brake hoses, hand brake shoes (×4), hand brake cables (×2), wear indicators. Front wheel bearings (×2) with safety rings and retainers. Tail lights (left + right, €498.74)...

Engine reassembly: complete motor disassemble/assemble (€3,600), lower engine casing (€1,250), assembly material, cleaning and painting engine parts (black & colored). Brake caliper lacquering (front & rear, €99). Gearbox cover (€684.76), gear cover gasket, shift rod retainer. Spark plugs (×12), ...

Complete car interior and exterior assembly workmanship (€4,500). Mechanical labor (€900). Prepare and paint engine fan, rear blower housing, pedals, helper springs, exhaust tail. Wiper blades, license plates, hood dampers, license plate light, battery terminal with switch, door sill protection (...

Steering wheel contact, horn contact screw, handbrake console cup, storage box. Reconditioned transmission (€3,000). Flying pineapple coupling. Final commissioning and road testing.

DME relay (Relet DME) replacement. Disassemble/assemble steering rack and check alignment (€275). Sport steering wheel fitted. Reconstructed address unit (€267.95). A/C module fan disassemble/assemble and replacement (€500), replace cab holder module and console under handbrake. Exhaust silencer ...

Valvoline Synpower 5W40 A40 synthetic oil service, original oil filter, crankcase and engine washers, general condition checks, disassembly/assembly of A/C protections, road test, relocate heating pipe in pilot zone.

Fuel pump replacement, crankshaft sensor replacement, contact box replacement. Modify electrical installation of collector connector and replace collector.

Major service: 7 fuel lines replaced (various OE part numbers, ~€1,516 in fuel lines alone). Delco distributor covers (×2), rotors (×2), ignition coils (×2), ignition modules (×2). Fuel pressure regulator (€519.10). Repair and calibration of all 6 injectors (€495). Engine filler cap, pressurized ...

Exchange starter motor Bosch 996604107CX (list €1,152.20, 40% discount = €691.30). Express saver shipping (€39). Labor: 3 hours.

Full inspection — technician noted car almost completely restored, very nice. Oil service (Mobil 1 15/50 full synthetic, 10.5qt), Porsche oil filter. Motul LS 75/90 gear oil (×2). Motul 700 brake fluid. Brake fluid flush & refill (racing-level fluid). Transmission fluid flush & refill. Passenger ...

Full PPF Driver Package — bonnet leading edge, front bumper, mirrors, sills, door edges protected.

Steering rack: diagnosed power steering fluid leak from rack itself. Removed defective rack, fully disassembled, replaced all seals with new, repainted correct Porsche silver color, removed/replaced outer boots, pressure-tested unit and internal relief valve, re-installed and assessed alignment, ...